Farm pro tractor when the first start is unsuccessful, you should stop for a while and then start again, with an interval of not less than 30 seconds; each start time should not exceed 5 seconds, and continuous starts should be avoided; you can also use the method of having another person turn the crankshaft with a rocker while the electric start is started. use it together to try to start it successfully in one time; for a simple hand-cranked engine, it is necessary to heat the water (about 90℃) to preheat the engine before starting, and turn off the water release switch to let the hot water circulate in the body until the hot water flows out. Turn the switch, and then use the crank to rotate the crankshaft dozens of times to fill all parts with engine oil and get lubrication to reduce starting resistance; it is strictly forbidden to use unscientific methods of heating the oil pan with an open flame or baking the oil pan to prevent fire. After the engine is started, the preheating time should be appropriately extended and insulation equipment should be installed in front of the radiator to make the water temperature reach above 80°C as soon as possible. The engine is not allowed to operate at low temperatures for a long time.
Farm pro tractor when starting, you can use hot water around 80°C to increase the engine temperature, and turn on the water release switch. When the hot water around 40°C flows out, add boiling water to start. When the temperature is particularly cold, you can drain the engine oil and heat it to 40-50°C before adding it to the oil pan.It is strictly prohibited to use wrong methods to start, such as dragging, baking the car with an open flame, adding water after starting the car, adjusting the fuel injection pressure, etc.
At the same time, thickened engine oil can be used instead of ordinary engine oil. The battery power should be sufficient. Low battery power will cause difficulty in starting when it is cold, so the farm pro tractor should be parked indoors in a warm and wind-proof room.In order to prevent the cooling water from freezing, you can choose to drain the water from the water pump. When draining the water, wait until the water temperature drops to avoid burns. After draining the water, shake the crankshaft for several weeks to drain the water in the water pump housing. Do not turn off the drain switch. Finally, Mark "water has been released" in a conspicuous place. You can also choose antifreeze instead of cooling water.
It is indeed not easy to start the Farm pro tractor in winter. Be patient and check the operation manual more often. If you can't figure it out, contact maintenance as soon as possible and don't force yourself too much.
(Everyone's equipment will be different, and all operations must first follow the factory manual or operating instructions.)
